IMPLEMENTATION OF AUTOMATIC PUMP CONTROL ON SEA WATER DESTILATION SYSTEM
Abstract
This study aims to design an automatic pump control system and assess the effectiveness of using pumps in seawater distillation systems. The system uses an Arduino Uno microcontroller for central control of all system activities and a relay as a pump switch. Ultrasonic sensors, pH sensors and TDS sensors as input to provide information on the condition of the water in the storage container, the water pump as an output for pumping and flowing sea water and distilled water. The water pump in the seawater distillation system is used to drain seawater to the initial reservoir with a water level set point >20cm, if the set point is met, the pump will turn on. The second mini pump is used to flow the distilled water to the final reservoir with a set point value of pH <8 and a TDS value <1400, so the pump will turn on. The third mini pump is used to flow distilled water to the second basin with a set point value of pH >8 and a value of TDS >1400, so the pump will turn on, therefore the use of a pump in an automatic seawater distillation system is needed and its use can be said to be effective.
Keywords: Water Pump, Relay, Control
Downloads
References
L. I. Tarigan, S. D. Saripurna and S. Murniyanti, “Rancang Bangun Mesin Pompa Air Otomatis Untuk Penyaluran Air Dari Tangki ke Kran Pengambilan Air di Desa Regaji Menggunakan Teknik Counter Berbasis Mikrokontroler,†Teknologi Sistem Informasi dan Sistem Komputer TGD, vol 3, pp. 81-87, 2020.
S. Samsugi and A. Burlian, "SISTEM PENJADWALAN POMPA AIR OTOMATIS PADA AQUAPONIK MENGGUNAKAN MIKROKONTROL ARDUINO UNO R3," in Seminar Nasional Teknologi Fakultas Teknik Universitas Krisnadwipayana, Jakarta, 2019.
H. I. Rosyadi, N. K. Caturwati and A. Maulana, "Rancang Bangun Alat Destilasi Air Laut Menjadi Air Tawar Menggunakan Tenaga Surya," Jurnal TEKNIKA, vol. 12, pp. 431-438, 2016.
M. Ali, M. Lazim, A. Muin and I. Badil, "Penyulingan Air Laut Menjadi Air Tawar," Desiminasi Teknologi, vol. 7, 2019.
B. Mulyanef and K. Muslimin, "Pengolahan Air Laut Menjadi Air Bersih Dan Garam Dengan Destilasi Tenaga Surya," Jurnal Teknik Mesin, vol. 4 No 1, pp. 25-29, 2014.
U. Latifa and J. S. Saputro, "PERANCANGAN ROBOT ARM GRIPPER BERBASIS ARDUINO UNO MENGGUNAKAN ANTARMUKA LABVIEW," ISSN : 1979-889X (cetak), ISSN: 2549-9041 (online), vol. 3 No 2, pp. 138-141, 2018.
Sunarti, "Sistem Kendali Pompa Otomatis Pada Alat Desalinasi Air Laut Sebagai Sumber Air Minum Berbasis Arduino Uno," Kementrian Perindustrian RI Politeknik ATI Makassar, 2018
M. Arifin, "Efektifitas Sistem Pengaman Pompa Air Berbasis PLC," Universitas Negeri Semarang, 2016
Suwitno, "Mendisain Rangkaian Power Supply pada Rancang Bangun Miniatur Pintu Garasi Otomatis," Jurnal of Techonlogy, ISSN : 2502-3624, vol. 1 No 1, 2016
M. Elijah, HC-SR Ultrasonic Sensor Datasheet, 2014.
Copyright (c) 2020 Electro Luceat
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
